Preview

FLASH POINT OF BINARY MIXED SOLVENTS AND EFFECT ON ITS FORMATION INTERMOLECULAR HYDROGEN BONDS

Abstract

Binary mixed solvents based on propanol-1 and butanol-1 alcohols were investigated. As a second component of binary solvent polar organic liquids (acetic acid, heptanol, nitrobenzene) and nonpolar (triethanolamine) and 5 % solution of surfactant (sodium dodecyl sulphate) were investigated. The optimum content of the second component in the mixed solvent was 8 %. The greatest effect in increasing the flash point is achieved using acetic acid and heptyl alcohol. When using acetic acid, the temperature raising effect flashes propyl and butyl alcohol was 18,6 and 21,3 %, respectively. This is due to the polarity of the molecules and the ability to form intermolecular hydrogen bonds with the molecules of propanol and butanol. Addition of a 5 % solution of sodium dodecylsulfate resulted in increase of point flash butanol-1 and propanol-1 on 12,2 and 12,5 %. Analysis of experiments with triethanolamine was proved the influence of intermolecular hydrogen bonds on the flash point for polar liquids. The use of mixed solvents allows to reduce fire danger.

About the Authors

O. V. Bezzaponnaya
Ural State Fire Service Institute of Emercom of Russia
Russian Federation


A. Yu. Akulov
Ural State Fire Service Institute of Emercom of Russia
Russian Federation


O. A. Mokrousova
Ural State Fire Service Institute of Emercom of Russia
Russian Federation


I. A. Kaybichev
Ural State Fire Service Institute of Emercom of Russia
Russian Federation


N. V. Khabibullina
Ural State Fire Service Institute of Emercom of Russia
Russian Federation


L. O. Zhivotinskaya
Ural State Fire Service Institute of Emercom of Russia
Russian Federation


References

1. УразаевВ. И. Растворители // Технологии в электронной промышленности. - 2006. - № 2. - С. 14-19.

2. Беззапонная О. В. Влияние образования межмолекулярных водородных связей в бинарных растворителях на температуру их воспламенения // Техносферная безопасность. - 2014. - № 1(2). - С. 2-6. URL: http://uigps.ru/content/nauchnyy-zhurnal (дата обращения: 04.04.2015).

3. Беззапонная О. В. Исследование влияния межмолекулярных водородных связей в бинарных растворителях на температуру их воспламенения // Техносферная безопасность. - 2015. - № 1(6). - С. 9-13.URL: http://uigps.ru/content/nauchnyy-zhurnal(дата обращения: 04.04.2015).

4. Корольченко А. Я., Корольченко Д. А. Пожаровзрывоопасность веществ и материалов и средства их тушения : справочник. - В 2 ч. - М. : Пожнаука, 2004. - Ч. 1 - 713 с.

5. Корольченко А. Я., Корольченко Д. А. Пожаровзрывоопасность веществ и материалов и средства их тушения : справочник. - В 2 ч. - М. : Пожнаука, 2004. Ч. 2. - 774 с.

6. Liaw H.-J., Chiu Y.-Y. The prediction of the flashpoint for binary aqueous-organic solutions // Journal of Hazardous Materials.- 2003.- Vol. 101,No. 2.-P. 83-106. DOI: 10.1016/S0304-3894(03)00168-7.

7. Catoire L., Paulmier S., Naudet L. Estimation of closed cup flash points of combustible solvent blends // Journal of Physical and Chemical Reference Data. - 2006. - Vol. 35, No. 1. - P. 9-14. DOI: 10.1063/1.1928236.

8. Vidal M., Rogers W.J., Mannan M. S. Prediction of minimum flash point behavior for binary mixtures // Process Safety and Environmental Protection. - 2006. - Vol. 84, No. 1. - P. 1-9. DOI: 10.1205/psep.05041.

9. Liaw H.-J., Lin S.-C. Binary mixtures exhibiting maximum flash-point behavior // Journal of Hazardous Materials. - 2007. - Vol. 140, No. 1-2. - P. 155-164. DOI: 10.1016/j.jhazmat.2006.06.050.

10. Батов Д. В., Мочалова Т. А., Петров А. В. Исследование температуры вспышки бинарных неводных смесей жидкостей с положительным и отрицательным отклонениями от закона Рауля // Пожаровзрывобезопасность. - 2014. - Т. 23, № 1. - С. 25-29.


Review

For citations:


Bezzaponnaya O.V., Akulov A.Yu., Mokrousova O.A., Kaybichev I.A., Khabibullina N.V., Zhivotinskaya L.O. FLASH POINT OF BINARY MIXED SOLVENTS AND EFFECT ON ITS FORMATION INTERMOLECULAR HYDROGEN BONDS. Pozharovzryvobezopasnost/Fire and Explosion Safety. 2015;24(7):28-34. (In Russ.)

Views: 372


Creative Commons License
This work is licensed under a Creative Commons Attribution 4.0 License.


ISSN 0869-7493 (Print)
ISSN 2587-6201 (Online)